Product ID:TYPE II WALKWAY NONSLIP M. GRAY, G-8870
MSDS Date:03/26/1990
FSC:8010
NIIN:00N057627
MSDS Number: BWQXP

AKRON PAINT & VARNISH INC

1390 FIRESTONE PKWY
AKRON, OH 44301
US

Emergency Phone: 216-773-8911

Info Phone: 216-773-8911

Cage: HO385

AKRON PAINT AND VARNISH INC

AKRON, OH 44301-1624 US

Telephone: 216-773-8911

Cage: 70228

VM & P NAPHTHA (CONTAINS LESS THAN 8% OF INGREDIENT 2).

CAS: 64742-89-8

Fraction By Weight: 20-50%

OSHA PEL 300 PPM (MFR)

ACGIH TLV: 300 PPM (MFR)

XYLENE (SARA 313) (CERCLA)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: <8%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM;150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 20-50%

OSHA PEL SEE TABLE Z-3

ACGIH TLV: 0.1 MG/M3 RDUST

OBTAIN MEDICAL ATTENTION.

RTECS: 9999999ZZ

ANTICIPATED TO BE

RTECS: 9999999ZZ

MOVE AFFECTED

RTECS: 9999999ZZ

BREATHING HAS STOPPED, GIVE ARTF RESP. KEEP PERSON

RTECS: 9999999ZZ

MAY BE TAKEN UP W/SAND, FLOOR ABSORB/OTHER

RTECS: 9999999ZZ

SEWERS & BODIES OF WATER - NOTIFY PROPER AUTHORITIES

RTECS: 9999999ZZ

OF ACGIH TLV LIMIT, AND VOLATILES BELOW LOWER

RTECS: 9999999ZZ

LOWER LEVELS OF AREA & ALL IGNIT SOURCES

RTECS: 9999999ZZ

WILL BE ENCOUNTERED. REMOVE DECOMP PRODUCTS FORMED

RTECS: 9999999ZZ

FOR BAKING FINISHES - VENT VAPORS EMITTED ON

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE REDNESS, IRRIT,
SWELLING & BLURRED VISION. SKIN: PRLNGD/RPTD CONTACT CAN CAUSE
MODERATE IRRIT, DEFATTING, DERM. INHAL: EXCESS INHAL OF VAPS/SPRAY
MIST CAN CAUSE RESP IRRIT, DIZZ, WEAK, FATIGUE, NAUS, HEADACHE,
UNCON & EVEN ASPHYX. INGEST: CAN CAUSE GI IRRIT, NAUS, VOMIT &
DIARR; ASPIR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, SUPPLEMENT. VOL 7, PG 341, 1987: GROUP 2A. NTP 7TH
ANNUAL RPT ON (SUPDAT)
Effects of Overexposure:HLTH HAZ: OF MATERIAL INTO LUNGS CAN CAUSE
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: FLUSH W/LGE AMTS OF WATER FOR AT LEAST 15 MINS. LIFT
EYELIDS OCCAS, GET PROMPT MED ATTN. SKIN: WASH THORO W/SOAP &
WATER, REMOVE CONTAMD CLTHG PROMPTLY; WASH CLTHG BEFORE REUSE.
CONSULT MD IF IR RIT PERSISTS. INGEST: DO NOT INDUCE VOMITING! KEEP
PERSON WARM, QUIET & GET MED ATTN. ASPIR OF MATL NTO LUNGS DUE TO
VOMIT CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL. DRINK 1 TO 2 GLASSES
OF (ING 6)

Flash Point Method:TCC
Flash Point:50.0F,10.0C
Lower Limits:0.90%
Upper Limits:7.00%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND TO AN IGNIT SOURCE SOME DISTANCE FROM MATERIAL HANDLING
POINT. IGNIT SOURCES INCL PILOT LIGHTS, SMOKING, (SUPDAT)

Spill Release Procedures:SMALL SPILL: ABSORB LIQ W/RAGS, FLOOR ABSORB,
VERMICULITE/OTHER ABSORB MATL & TRANSFER TO HOOD. LGE SPILL: ELIM
ALL IGNIT SOURCES ---DIKE AREA OF SPILL TO PVNT SPREADING - VENT
AREA IF INDOORS - PUMP LIQUID INTO SALV TANK- REMAINING LIQ (ING
8)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT DROP CNTNRS. AVOID HEAT, SPARKS
& OPEN FLAME. STORE LGE QTYS ONLY IN BUILDINGS DESIGNED TO COMPLY
W/OSHA 1910.106. NEVER USE PRESS TO EMPTY.
Other Precautions:AVOID BRTHG SANDING DUST. DO NOT HNDL UNTIL MFRS
SAFETY PRECS HAVE BEEN READ & UNDERSTOOD.

Respiratory Protection:IN OUTDOOR/OPEN AREAS W/UNRESTRICTED VENT APPRVD
CHEM/MECH FILTERS DESIGNED TO REMOVE A COMBINATION OF PARTICUALTES
& VAP. IN CONFINED AREAS, NIOSH/MSHA APPRVD AIR LINE RESPS/HOODS.
Ventilation:PROVIDE SUFF VENT IN VOL & PATTERN TO KEEP AIR CONTAM CONC
BELOW CURRENT APPLIC OSHA PERMISSIBLE EXPOS LIMIT/(ING 10)
Protective Gloves:NITRILE RUBBER GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES.
Other Protective Equipment:NORMAL PROT CLTHG. WASH CNTAMD CLTHG BEFORE
REUSE. EYEWASH FOUNTAIN & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: HEATERS, ELEC MOTORS, SPARKS FROM ELEC SWITCHES & STATIC
DISCHARGES. CAUTION! NEVER USE CUTTING TORCH ON EMPTY CNTNRS!
RESIDUAL SOLV VAP IN EMPTY CNTNR MAY EXPLODE. APPLIC TO HOT SURFS
REQS SPEC PRECS. DURING EMER CNDTNS, OVEREXP TO DECOMP PRODS MAY
CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED APPARENT.(ING 4)

Boiling Pt:B.P. Text:0F,-18C
Vapor Density:HVR/AIR
Spec Gravity:1.37335
Evaporation Rate & Reference:6.71 X N-BUTYL ACETATE
Appearance and Odor:GRAY LIQUID.
Percent Volatiles by Volume:50.7

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS (E.G. NITRIC ACID).
Stability Condition to Avoid:KEEP AWAY FROM HEAT & OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE & DIOXIDE,
VARIOUS HYDROCARBONS, ETC.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.